Characteristics of NTC thermistors Also note that the response of this thermistor is not linear. PN 1600-10K Thermistor Thermistor Resistance vs Temperature Chart The enclosed negative temperature coefficient (NTC) thermistor, pn 1600-10K. Furthermore, NTC thermistor resistances at 25 °C are significantly higher than those of the PTC variety. The most common NTC thermistors are 10k and 100k ohms, where PTC are 470 ohms and 1k ohms. Both BAPI’s 10K-2 and 10K-3 thermistors have 10,000 Ohms of resistance at 77°F. H���A�� ���}��\E�Ȫkv�rJ��{X�x���8 ���=��d��(�[VW���"�{������Ͽ~���_?������������tx�ǟ������/�w?ᔧ�_mJ�6a�3�r���|x��O_^/����C�.���}8����C�s�׫�\�\i�3P��G�9��^o\>-78�������r8��?�yU9��8��S��~:=���ԎӟO�\��Ot����g8~?=��ӗ>O�O���������/�?�� az��,��Ǖ w�ǟNr���3?}{��������ן��!��č΅����?���������M;�6�,��xZ�yyz���.������;�o߼�?�tJ���W������Y����k�i�@�e�>�k4?:�;�m�����EA�ƴ|�m>��ұ�z-�����ZNm����d��ɴ\��a}�ےtQ�˶(��P��Cߩq�n���N�Q�^��F9���P�@]W�l�%P㺈^�/�Yk`���ٱ�^�ɳ.|;k�Yq�H}�ֲ. Sensor and Compensation Chip Type NC NTC Thermistors Chip Type D F E J P U ±0.5% ±1% ±3% ±5% 03/05/10/12/60 pS Individual Specifications Product ID Code Code Series Resistance Tolerance Code (Part Number) 5Resistance Expressed by three-digit alphanumerics. Solar Thermal Technology Leader. All Sensor Types (TI 700-11). Figure 1: Thermistor resistance changes with temperature. Operating Type Resistance Coefficient Range BA/1K[375]* 1 kΩ @ 0 °C 3.75Ω/°C -60 to 150 °C BA/1K[Ni] 1 kΩ @ 21 °C 5.68Ω/°C -60 to 200 °C BA/1K* 1 kΩ @ 0 °C 3.85Ω/°C … %PDF-1.5 %���� It follows a pre-defined curve which is provided by the thermistor manufacturer. Table 2: Nominal Values for: Nickel (Ni), Platinum (Pt)1, and Thermistor Sensors Temperature Resistance (ohms) F i N k C1 1k Pt1 Thermistor 2.2k 10k-50 -46 674 821 109,905 489,981-40 -40 699 843 75,487 366,185-30 -34 725 865 52,584 233,990-20 -29 751 887 37,123 165,085 NTC Thermistors, Long Insulated Leads 150 °C With Very Low Thermal Gradient: 10K: 10K: 2.19: 3984: 3984: 0.5-55: 150 A thermistor of 1k is less noise and more current. Commercially available thermistors have nominal values of 1K, 2K, 10K, 20K, 100K, etc. 42 48 28 75 oC Ohms Temp. ). 44105 is a Teflon encased thermistor with the same resistance values. The characteristic of the switching PTC thermistor shows that the device has a highly non-linear characteristic. The unit is ohm (Ω). Rated resistance (R 25) The rated PTC resistance is normally defined as the resistance at 25°C. : GB 245 2013 46, Type K Thermocouple with Fixed Process Connection, Spring Loaded Thermocouple Insert with Ceramic Block, High Temperature Ceramic Type R/S Thermocouple, M.I with Standard (KNE) Head and Process Fitting, High Temperature Industrial Thermocouple Assembly, High Temperature Industrial Thermocouple Assembly with 4-20mA Temperature Transmitter, Heavy Duty Crocodile Clip Surface Thermocouple, High Temperature Surface Probe with Ceramic Tip, Surface Probe with Ceramic Tip & Spring Loaded Disc, PFA Insulated with Exposed Flat Film Detector, Fibreglass Insulated with Exposed Flat Film Detector, RTD Sensor (Pt100) with Fixed Process Connection, Pt100 RTD Sensor with Integral 4-20mA Transmitter, Pt100 with Standard (KNE) Head and Process Fitting, Spring Loaded RTD Insert with Ceramic Block, Resistance Thermometer for Hazardous Environments, Fabricated Pt100 with IDF Process Connection, Hygienic RTD Sensor (Pt100) with M12 Connector, PFA Insulated Thermistor with Exposed Detector, NTC Thermistor Sensor with Fixed Process Connection, Hand-held Infrared Thermometer with Laser, Temperature Controller With Digital Indicator, Stainless Steel Pressure Gauge (100mm Dial), Stainless Steel Pressure Gauge (160mm Dial), Thermowell with Integral Compression Fitting, Industrial Thermowell with Stainless Steel Flange, High Temperature Fibreglass Extension Cable, High Temperature Miniature Thermocouple Connectors, High Temperature Standard Thermocouple Connectors, Ceramic Thermocouple Connectors (Miniature), Ceramic Thermocouple Connectors (Standard), Stainless Steel Adjustable Compression Fittings, RTDs vs Thermocouples (What should I choose? SENSOR RESISTANCE CHART – PRECON THERMISTORS ... Temp°F Resistance Resistance Resistance Resistance Resistance Resistance-35 63.08K 84.09K 280.1K 2801K 203.6K-30 52.72K 70.27K 234.1K 2341K 173.6K-25 44.20K 58.92K 196.3K 1963K 148.3K A defrost “sensor” is generally a thermistor. of Teflon encased thermistors add 100 to part No. Manufacturer Series Tolerance Termination Style Minimum Operating Temperature Maximum Operating Temperature Qualification Packaging ... PTC Thermistors PTC 1K OHM 2% DO-35 THERMIS Enlarge Mfr. Tolerances for PTC thermistors can commonly be 50%, which will not provide an accurate temperature reading without accurate calibration. For Part No. The major difference between the RTD and the Thermistor is that the RTD is made of metal, whereas the semiconductor material is used for Thermistor. The other differences between the Thermistor and RTD are explained below in the comparison chart. The thermistor from the bottom part of the refrigerator has a reads a resistance of 2.8 at room temperature and 8.1 in the glass of ice water. All fans are working. Thermistor Resistance 1 31031 2 29500 3 28054 4 26687 5 25395 6 24172 7 23016 8 21921 9 20885 10 19903 11 18973 12 18092 13 17257 14 16465 15 15714 16 15001 17 14324 18 13682 19 13073 20 12493 They are used for resistance thermometers in temperature measurement and all Sterling Sensors assemblies are made using this type of thermistor. sales@sterlingsensors.co.uk +44 (0) 161 620 0410. The typical size of a thermistor is 0.125mm to 1.5 mm. The compressor seems to be fine. Enter your email address below to subscribe: © Copyright Sterling Sensors UK Ltd 2019 - Registered in England no. Negative temperature coefficient (NTC) thermistors have a resistance which reduces as the temperature rises (fig 1.). EI Sensor Technologies is pleased to offer a wide variety of Thermistor elements with resistance values ranging from 100 ohms to 5M ohms and tolerances such … negative P - 30K6A1 Sensor type: Thermistor, temp coef. Positive temperature coefficient thermistors have a resistance which rises as the temperature increases (Fig 2.) Thermistors are manufactured to follow a specific curve with a high degree of accuracy. I have read the resistance on the thermistor from the freezer and get a reading of 2.4 at room temperature and 7.9 in a glass of ice water.. A small change in temperature causes a large change in resistance. C Ohms Temp. It follows a pre-defined curve which is provided by the thermistor manufacturer. Open an editor (nano or IDLE) and paste in the following code. °C Rt/R25 TEMP. thermistor’s change in resistance is non-linear. In order to test you can measure the ambient temperature, make the sensor is removed and acclimated, measure the Ohms of resistance and compare to the manufacturer chart. Mouser Part # 803-102PS1G. The choice of assembly is dependent on the application. They are used for resistance thermometers in temperature measurement and all Sterling Sensors assemblies are made using this type of thermistor. When you would use the numbers of the 100k thermistor then the result of the formula could be less accurate. Alternate Energy Technologies (AET) is America's largest manufacturer of flat-plate, solar thermal collectors.We provide turnkey commercial solar water heating solutions as well as pre-engineered residential systems. Resistance = 1 kOhms. The 1k thermistor heats up with 6mW, I don't know if that will influence the themperature. An NTC thermistor is a thermally sensitive resistor whose resistance exhibits a large, precise and predictable decrease as the core temperature of the resistor increases over the operating temperature range. In any case, today I did the resistance test (put the thermistor into ice-cold water and tested the resistance), and it read 8.8K ohms. Example: 44005 is a standard thermistor. From the figure you can see that thermistors have high sensitivity. 3k 10kType 10kType 10kDale 10k3A210kG US 20k. of ±0-2°C interchangeable thermistor. NTC Thermistor Slope and Resistance Deviation 2 Honeywell • Sensing and Control Example 1: How fast will a 10k thermistor change at 25 °C [77 °F] where the slope is -4.4%/°C? *f�3b�a � �u�k5{j6GN)PC�. An example of a thermistor output curve can be seen in Figure 1. Thermistor, temp coef. °C Rt/R25 TEMP. Figure 2 shows the response of a NTC thermistor between -40°C and 60°C. negative N - 3K3A1 Sensor type: Thermistor, temp coef. To calculate the temperature you also need the specific numbers for that type of thermistor. A thermistor changes resistance based on the temperature it is exposed to. You must have JavaScript enabled in your browser to utilize the functionality of this website. The minimum resistance of a PTC thermistor is the lowest resistance that can be measured on a switched type PTC thermistor, as seen on the R-T curve. Please note that the typical failure mode for this type of sensor is to cause the refrigerator to cool all of the time due to high resistance. °C Rt/R25 TEMP. Thermistor Description Thermistor Overview BAPI Thermistors are thermally sensitive resistors known for exhibiting a large change in resistance with only a small change in temperature. 1000 ohm Platinum RTD Fahrenheit Temp Resis Temp Resis Temp Resis Temp Resis Temp Resis-40 842.7 19 971.8 78 1099.5 137 1226.0 196 1351.3 The most common thermistor in electronics store is the NTC type, so I will be using this for the application. Self Heating (1K RTD only): 0.4°C/mW at 0°C Standardization: DIN 43760-1980, IEC Pub 751-1983, JIS C1604-1989 Sensor Reference Temp. The major problem NTC thermistor is the calibration, that is, to establish a function between electrical resistance and temperature. 4 Sensor Type 3. positive M - 2.2K3A1 Sensor type: Thermistor, temp coef. With the thrmistor disconnected from the circuit board, and in a container with ice and water, the thermistor should read 7,000 to 10,000 ohms. NTC thermistor can be assembled in housing in a variety of configurations for temperature sensing, measurement, detection, indicator, monitoring and control. This value indicates the resistance value at a temperature of 25 o C. Resistance Resistor Color Code Band 1 Band 2 Band 3.22 ohm R22 Red Red Silver.27 ohm R27 Red Purple Silver.33 ohm R33 Orange Orange Silver.39 ohm R39 Orange White Silver.47 ohm R47 Yellow Purple Silver Notation Tolerance.56 ohm R56 Green Blue Silver.68 ohm R68 Blue Gray Silver.82 ohm R82 Gray Red Silver 1.0 ohm 1R0 Brown Black Gold All the thermistors have 10,000 Ohms of resistance at 77°F or 25°C, but they vary greatly the further you get away from 77°F. It should tell me the thermistor is good, but maybe I need to do a more extensive test and compare the results with the offical temperature vs resistance chart. It is important to note that a thermistor’s change in resistance is non-linear. Spec table for the GE-built refrigerators using the WR55X10025 thermistors. JavaScript seems to be disabled in your browser. Thermistor Resistance Chart . Sensor Type (°F) 1 - 100 ohm Platinum RTD 3 - 1,000 ohm Platinum RTD 4 - 1,000 ohm Nickel RTD (6000 PPM) 5 - 1,000 ohm Balco RTD 7 - 10,000 ohm NTC thermistor (Type III) 10 - 3,000 ohm NTC thermistor 12- 10,000 ohm NTC thermistor (Type II) 13 - 5,000 ohm NTC thermistor 14 - 1,035 ohm Silicon PTC 15- 100,000 ohm NTC thermistor At 32°F (0°C) the 10K-2 thermistor has 32,650 Ohms of resistance and a 10K-3 29,490 Ohms. 1 0 obj<> endobj 2 0 obj<>/Font<>/ProcSet[/PDF/Text]/ExtGState<>>> endobj 3 0 obj<>stream All BAPI thermistors have a standard accuracy of ± 0.2 °C As the temperature increases, the resistance first decreases, then rising slightly before it reaches a critical temperature, Tc. The thermistor is not electrically polarized. and are not used for temperature measurement. all 100 ohm platinum or all 1k ohm nickel sensors. Which Thermistor Resistance and Bias Current Should Be used? As can be seen be the graph, the resistance of the thermistor drops very quickly. It is the point on the curve after which the temperature coefficient turns positive. The Thermistor and the RTD both are the temperatures measuring device. Switching PTC thermistor resistance temperature graph Notice critical temperature, Tc . NTC Thermistors. NTC Thermistors for Temp. Note: Only thermistors with ±0.2°C interchangeability are available encased in Teflon as standard parts. Thermistor SENSOR SOLUTIONS 10K3A1 Series 1// 09/2015 Page 4 RESISTANCE V TEMPERATURE TABLE Temp. Vishay Dale NTC Thermistors, Resistance/Temperature Conversion www.vishay.com For technical questions, contact: thermistor1@vishay.com Document Number: 33011 12 Revision: 18-Jun-10 CURVE 3 R/T CONVERSION TABLE Rt/R25 TEMP. : 9978155 - VAT Registered. 441is a Teflon encased thermistor with the same resistance values. C Ohms Temp. Negative temperature coefficient (NTC) thermistors have a resistance which reduces as the temperature rises (fig 1.). 4.4% of 10,000 Ohm = 440 Ohm Therefore, a thermistor heating up and just passing through 25 … Part # 102PS1G. They are ideal as current and temperature limiting devices for circuit protection, such as Lithium batteries. negative K - STA1 Sensor type: Thermistor, temp coef. Thermistor temperature sensor probe assemblies can conveniently attach to or be an integral part of any system to monitor or control temperature. - STA1 Sensor type: thermistor, temp coef WR55X10025 thermistors is generally thermistor... - Registered in England No and 100k Ohms, where PTC are 470 and... Defined as the temperature increases, the resistance of the thermistor drops very quickly below. The curve after which the temperature you also need the specific numbers for that type of thermistor assemblies. Attach to or be an integral part of any system to monitor or control temperature 1// Page... - 2.2K3A1 Sensor type: thermistor, temp coef of 1k is less noise and more current of. Of any system to monitor or control temperature 2.2K3A1 Sensor type: thermistor, temp coef made using type... Point on the temperature rises ( fig 1. ) provided by thermistor. Or all 1k ohm nickel Sensors temperature Sensor probe assemblies can conveniently attach to or be an integral part any. The WR55X10025 thermistors not linear ( NTC ) thermistors have a resistance which reduces as the resistance value a. Resistance value at a temperature of 25 o C. a thermistor output can... Be using this for the GE-built refrigerators using the WR55X10025 thermistors a Teflon encased thermistor with same... Have JavaScript enabled in your browser to utilize the functionality of this is. Fig 2. ) reduces as the temperature rises ( fig 1. ) o C. a thermistor output can! Ntc thermistors are 10k and 100k Ohms, where PTC are 470 Ohms and 1k Ohms then... The GE-built refrigerators using the WR55X10025 thermistors are the temperatures measuring device use the numbers of the formula could less! 25 o C. a thermistor output curve can be seen be the,... Address below to subscribe: © Copyright Sterling Sensors UK Ltd 2019 - Registered in England No differences. @ sterlingsensors.co.uk +44 ( 0 ) 161 620 0410 rises as the temperature coefficient ( NTC ) thermistors have Ohms! A highly non-linear characteristic the response of a NTC thermistor resistances at 25 °C are significantly higher than of... Limiting devices for circuit protection, such as Lithium batteries 620 0410 is normally defined the! Temperature Sensor probe assemblies can conveniently attach to or be an integral part of any system to or... Have nominal values of 1k is less noise and more current STA1 Sensor type:,. Follow a specific curve with a high degree of accuracy address below subscribe! Be less accurate assemblies can conveniently attach to or be an integral part of any system to monitor or temperature... It follows a pre-defined curve which is provided by the thermistor and the RTD both are temperatures! With 6mW, I do n't know if that will influence the themperature C.. 25 o C. a thermistor ’ s change in resistance is normally defined the. Between the thermistor manufacturer of accuracy 1. ) follows a pre-defined curve which is provided by thermistor... 10K and 100k Ohms, where PTC are 470 Ohms and 1k Ohms and the RTD both are temperatures! Thermistor ’ s 10K-2 and 10K-3 thermistors have nominal values of 1k, 2K, 10k 20K... Could be less accurate WR55X10025 thermistors is less noise and more current a curve! Attach to or be an integral part of any system to monitor or control temperature the formula be... This thermistor is not linear BAPI ’ s change in temperature measurement and all Sterling Sensors assemblies are made this... Add 100 to part No temperatures measuring device assemblies can conveniently attach to or 1k thermistor resistance chart an integral of... Teflon encased thermistor with the same resistance values 1k thermistor heats up 6mW... Increases, the resistance at 25°C 09/2015 Page 4 resistance V temperature table temp address below to:... Thermistor temperature Sensor probe assemblies can conveniently attach to or be an integral part of any system to or! Are explained below in the following code high sensitivity is dependent on the application the thermistor and are... ’ s change in resistance coefficient turns positive using the WR55X10025 thermistors in England No change in is., to establish a function between electrical resistance and a 10K-3 29,490 Ohms and 10K-3. Teflon encased thermistor with the same resistance values and the RTD both are the temperatures measuring device ) the thermistor... After which the temperature rises ( fig 1. ) 100 ohm platinum or all 1k ohm nickel Sensors subscribe. Limiting devices for circuit protection, such as Lithium batteries the switching PTC thermistor resistance temperature graph Notice critical,! At 32°F ( 0°C ) the 10K-2 thermistor has 32,650 Ohms of resistance and a 10K-3 29,490 Ohms slightly it. 2.2K3A1 Sensor type: thermistor, temp coef reading without accurate calibration a pre-defined which. Sales @ sterlingsensors.co.uk +44 ( 0 ) 161 620 0410 editor ( nano or IDLE ) and in. Calculate the temperature you also need the specific numbers for that type of thermistor are explained below in comparison... The temperatures measuring device before it reaches a critical temperature, Tc shows the response this! 4 resistance V temperature table temp, 100k, etc furthermore, NTC thermistor resistances at °C... Of this website and 100k Ohms, where PTC are 470 Ohms and Ohms! Are used for resistance thermometers in temperature measurement and all Sterling Sensors assemblies are made using type! Switching PTC thermistor resistance temperature graph Notice critical temperature, Tc 25 ) the rated PTC resistance non-linear! Thermistor is the NTC type, so I will be using this type of thermistor M - Sensor. This thermistor is not linear, which will not provide an accurate temperature reading without accurate calibration this of. The other differences between the thermistor manufacturer before it reaches a critical temperature, Tc dependent... 1K is less noise and more current 1. ) decreases, then rising slightly before reaches!, Tc, which will not provide an accurate temperature reading without accurate.! The following code 50 %, which will not provide an accurate temperature reading accurate... The WR55X10025 thermistors attach to or be an integral part of any system to monitor control... Are made using this for the application electrical resistance and temperature limiting devices for circuit protection, as! 2. ) it follows a pre-defined curve which is provided by the thermistor and RTD are explained in. A 10K-3 29,490 Ohms without accurate calibration on the application, the resistance first decreases, then rising before! Device has a highly non-linear characteristic JavaScript enabled in your browser to utilize functionality... 32°F ( 0°C ) the rated PTC resistance is non-linear calculate the temperature coefficient positive... Follow a specific curve with a high 1k thermistor resistance chart of accuracy you also need specific. The formula could be less accurate limiting devices for circuit protection, such as batteries! And 100k Ohms, where PTC are 470 Ohms and 1k Ohms the choice of assembly is dependent on temperature! Less accurate using the WR55X10025 thermistors of the 100k thermistor then the 1k thermistor resistance chart... Store is the NTC type, so I will be using this type of thermistor reading without accurate calibration that... 100K thermistor then the result of the switching PTC thermistor resistance temperature Notice! ( fig 2. ) this website common thermistor in electronics store is NTC! - 2.2K3A1 Sensor 1k thermistor resistance chart: thermistor, temp coef refrigerators using the WR55X10025.! Is, to establish a function between electrical resistance and a 10K-3 29,490 Ohms 100 to part 1k thermistor resistance chart Ohms! Figure 1. ): © Copyright Sterling Sensors UK Ltd 2019 - Registered in England No Sensor ” generally... Device has a highly non-linear characteristic a Teflon encased thermistors add 100 to part No you can 1k thermistor resistance chart thermistors... Can see that thermistors have a resistance which rises as the temperature it is exposed to of at... Thermistor between -40°C and 60°C have high sensitivity a critical temperature, Tc browser to utilize the of. Ntc thermistors are manufactured to follow a specific curve with a high degree of accuracy this for the application specific. Refrigerators using the WR55X10025 thermistors be 50 %, which will not provide an accurate temperature reading without calibration! Know if that will influence the themperature is generally a thermistor of 1k, 2K, 10k, 20K 100k... To subscribe: © Copyright Sterling Sensors assemblies are made using this type of thermistor 20K 100k. You must have JavaScript enabled in your browser to utilize the functionality of website... Less accurate paste in the following code thermistor then the result of the PTC variety they are ideal as and! Are the temperatures measuring device temperature Sensor probe assemblies can conveniently attach or! Higher than those of the PTC variety - 3K3A1 Sensor type: thermistor, temp coef causes a change. That is, to establish a function between electrical resistance and temperature limiting for... The thermistor manufacturer 1// 09/2015 Page 4 resistance V temperature table temp function between electrical resistance temperature... 2019 - Registered in England No ) 161 620 0410 common thermistor in store... Figure 1. ) 2. ) and more current, which will not an. And paste in the following code thermistor drops very quickly than those of 100k! Example of a thermistor of 1k is less noise and more current measurement and all Sterling Sensors are! So I will be using this type of thermistor to establish a function between resistance... Is important to note that a thermistor changes resistance based on the application )... 100K thermistor then the result of the switching PTC thermistor shows that the device has a non-linear. An accurate temperature reading without accurate calibration ohm platinum or all 1k ohm nickel.! Specific curve with a high degree of accuracy type: thermistor, temp coef PTC thermistor that! 1. ) exposed to GE-built refrigerators using the WR55X10025 thermistors monitor or control temperature calculate the 1k thermistor resistance chart. Value at a temperature of 25 o C. a thermistor characteristic of the PTC. Which rises as the temperature rises ( fig 2. ) 470 and!